Reviewed October 1993
Contents
Use our feedback form for questions or comments about G1231.
Publication search
When Pirelli Co. developed the first radial tractor tire in 1957, the company claimed it would develop 20 percent greater traction with less slippage at equal load than an equivalent bias-ply tire. (Forrest, et al. 1962) Subsequent research has confirmed that radial tires have the advantage in tractive efficiency. H. Erdal Ozkan, state extension specialist at Ohio State University, has reviewed all available research results related to field performance of tractors equipped with radial and bias ply tires.
| Author | Increase in tractive efficiency for radials |
|---|---|
| Seleznev and Kovalez (1968) | 13 percent |
| Bohnert and Kenady (1975) | 7 percent |
| Hoffman (1983) | 8 to 9.5 percent |
| Hausz and Akins (1980) | 7 to 13 percent |
In most cases, the research was done with the same wheel slip for radial and bias tires. This may have kept the radial tires from reaching the predicted 20 percent advantage.
Drawbar pull tests were reported as follows:
| Author | Wheel slip | Soil | Advantage of radial |
|---|---|---|---|
| Forrest (1962) | less than 15 percent | Sand Loam Clay |
8 percent 23 percent 21 percent |
| Thaden (1962) | 16 percent | 29 percent | |
| Mumgaard and Rudakov (1975) | 15 percent | Firm | 15.5 percent |
| Bohnert and Kenady (1975) | Tilled Sod |
14.6 percent 18.8 percent |
|
| Gee-Clough (1977) | 20 percent | 5-8 percent |
Field capacity and fuel consumption were studied:
| Author | Increase in field capacity for radials | Reduction in fuel consumption for radials |
|---|---|---|
| Seleznev and Kovalez (1986) | 10.7 percent | 13 percent |
| B.F. Goodrich Co. (1981) | 12.3 percent | 12.8 percent |
| Bohnert and Kenady (1975) | 16.4 percent | |
| Hauck and Kucera (1983) | 2.1 percent | 6.5 to 8.1 percent |
| Hausz and Akins (1980) | 5 to 7 percent | 6 to 10 percent |
Conditions used by investigators were not constant, and results cannot be directly compared. Radial tires, however, do seem to have the advantage in every category except purchase price. Resistance to abrasive wear seems about the same for radial and bias tires, but radial tires have much longer tread life than bias tires. Radial tires will have service life 25 to 40 percent longer than equivalent bias tires (Ozkan, 1986).
Ownership cost usually includes depreciation, interest on investment, tax, shelter and insurance. For a comparison of tires, the difference in tax, shelter and insurance cost was thought to be negligible and was omitted. The capital recovery factor was used to estimate ownership cost because it accounts for both depreciation and return on investment.
To compute annual tire ownership cost; unit tire cost; fuel cost for radial and bias tires; labor cost for radial and bias tires; and total savings per hour and hours use required to break even, use the following equations:
Equation 1
| TOC = | TP(IR (1 + IR)n) (1 + IR)n - 1 |
Equation 2
| UTC = | TOC AU |
Fuel cost for radial and bias tires may be computed using Equations 3 and 4.
Equation 3
FB = GPH x UFC
Equation 4
FR = FB (1 - RF)
Labor cost for radial and bias tires may be estimated as follows:
Equation 5
| LR= | LB__ 1 + IFC |
Total savings per hour and hours required to break even are computed as follows:
Equation 6
NSH = (FB x FR) + (LB - LR) - (UTCR - UTCB)
Equation 7
| BE = | TPR - TPB NSH |
Assumed input data:
Tractor maximum PTO power = 150 hp
Tractor annual use = 625 hours
125 hours stationary (tires not used)
500 hours mobile (tires used)
Diesel fuel cost = $1 per gallon
Cost for 2 radial tires = $1,500
Cost for 2 bias tires = $1,000
Expected bias tire life = 2,500 hours (5 years)
Labor cost = $5.20 per hour
Increase in field capacity for radial tires = 10 percent
Expected increase in life for radial tires = 30 percent
Expected fuel saving for radial tires = 6 percent
Average interest rate = 9 percent
Fuel efficiency for tractors with bias tires = 14 hp-hours per gallon
Annual tire ownership cost (using Equation 1)
| TOCB = | 1000 (0.09(1 + 0.09)5 ) |
= $257.09 per year |
| TOCR = | 1500 (0.09(1 + 0.09)5) |
= $385.64 per year |
Unit tire cost (using Equation 2)
| UTCB = | $257.09 per year 500 hours per year |
= $0.51 per hour |
| UTCR = | $385.64 per year 500 hours per year |
= $0.77 per hour |
Fuel cost (using Equations 3 and 4)
Fuel efficiency with bias tires (given) = 14 hp-hours per gallon
| Fuel consumption = | ____150 hp____ 14 hp-hours per gallon |
= 10.71 gallons per hour |
FB = 10.71 gallons per hour x $1 per gallon = $10.71 per hour
FR = 10.71 (1 - 0.06) = $10.07 per hour
Labor cost (using Equation 5)
LB = $5.20 per hour
| LR | = | __LB__ 1 + IFC |
= | __5.20__ 1 + 0.10 |
= $4.72 per hour |
Total savings per hour (using Equation 6)
NSH = (10.71 - 10.07) + (5.20 - 4.72) + (0.77 + 0.51) = $0.86 per hour
Use required to break even (using Equation 7)
| BE = | 1500 - 1000 0.86 |
= 581.39 hours |
| _____581.39 hours_____ 500 hours mobile use per year |
= 1.16 years |
G1231, reviewed October 1993